Chilling Effect: Air-Conditioner Repairs Undermine Coolant Restrictions

Marcus Yam for The New York Times

A repair technician in New Jersey removed an air-conditioning unit that uses HCFC-22, which is banned for use in new units, to install a new one that uses a different coolant, R-410A.

When Mark Spector?s central air-conditioning system stopped cooling his Trumbull, Conn., home this summer, he sent an S O S to his repairman. What happened next illustrates the myriad challenges the United States faces as it tries to phase out the popular but environmentally devastating cooling gas that was in Mr. Spector?s unit.

The Environmental Protection Agency has tried to reduce use of this gas, HCFC-22, which depletes the ozone layer and contributes to global warming, by imposing strict quotas on its production. Since 2010, it has also banned the sale of new air-conditioning units containing the compound, and has promoted recycling of the gas from old machines so it will not be released.

But what followed at Mr. Spector?s home circumvented all the agency?s rules and good intentions: Instead of finding and repairing the hole in his aging unit, a complicated task, a serviceman pumped in more coolant, which leaked out by the next day. When Mr. Spector called around for another solution, a salesman offered to swap in a new condenser unit, but one that still used HCFC-22 ? meaning one more American home would continue relying on an environmentally damaging coolant for years.

HCFC-22 is being phased out of air conditioners worldwide under an international treaty called the Montreal Protocol, and the United States has aggressively pressed poor countries to pick up the pace. But the United States has yet to put its own house in order. And, with 140 million central air units still running on HCFC-22 in this country, it is a major offender.

Leaks abound in working equipment. Coolant seeps out of discarded equipment in landfills. Regulatory loopholes allow manufacturers to sell parts that rely on HCFC-22, so systems using the old gas can be refurbished rather than replaced. There is almost no reclamation of the gas from old machines for recycling. The E.P.A. is behind schedule in imposing rules to ratchet down domestic production, and smuggling is rarely detected. Even where there are regulations ? for example, repair technicians are legally bound to collect old gas rather than vent it ? there is little enforcement.

And, as Mr. Spector discovered, many of the environmental crimes and misdeeds that keep the country dependent on HCFC-22 happen on your property, most likely without your knowledge.

?It?s totally illegal to vent gas, but it?s also totally inconspicuous,? said Stephen O. Andersen, a former E.P.A. official who has campaigned for better controls on cooling gases. ?I always watch like a hawk when they?re in my yard,? he said of technicians.

The concentration of HCFC-22 in the atmosphere is 218 parts per trillion, more than double the amount two decades ago, and it gets there in a number of ways. Low-quality or old equipment leaks, and detecting the colorless and odorless gas without pressure-testing devices is difficult. Sometimes the release is intentional, because it costs less. For example, installing a new part properly usually requires first siphoning a machine?s coolant into a canister, for later replacement. But it is quicker, though illegal, just to cut the line. A technician saves half an hour on a job, and the customer gets a smaller bill.

Bobby Ring, who runs a servicing company in suburban New Jersey, said that makes it hard for him to compete. ?There are contractors out there who refuse to make the investment in recovery equipment to reclaim or recover refrigerants, and no one is looking, so ? phsssst ? they let the refrigerant escape,? he said.

Although large companies, which are required to report use of the gas, have been fined for large leaks, the E.P.A. has never prosecuted a residential service company for intentionally releasing HCFC-22.

Asked about the lack of backyard enforcement, David Bloomgren, a spokesman for the E.P.A., said it is ?a challenge to locate or obtain evidence of illegal venting,? so the agency focused on large polluters but encouraged homeowners to report possible backyard violations they observed to an E.P.A. tip site at epa.gov/tips/.

While it is hard to quantify exactly how much coolant is illegally released from America?s residential air conditioners, the E.P.A. estimates that only 7 percent of used coolant is turned in for recycling.

?The vast majority of it hits the sky,? illegally vented, said Kevin Zugibe, chief executive of Hudson Technologies Inc., a company set up to recycle HCFC-22. Under the Montreal Protocol, the United States has until 2015 to cut production and imports of newly made HCFC-22 to 10 percent of what it was a decade ago.

Without a much better supply of recycled HCFC-22, the United States will not be able to do that ? or have enough to service all the older air conditioners, grocery store freezers and other refrigeration equipment.

In the European Union, only recycled or reclaimed HCFC-22 can be legally used to service equipment. In Australia and Japan, recovery of the gas from old appliances is mandatory, and technicians receive a fee for collection.

Source: http://www.nytimes.com/2012/11/23/science/earth/air-conditioner-repairs-undermine-coolant-restrictions.html?partner=rss&emc=rss

ufc 144 fight card ufc 144 results acura nsx all star weekend 2012 giada de laurentiis howard hughes nationwide race